Slightly Glowing Series II Cat
#26
SARX Legend
iTrader: (46)
Only run premium in the Summer? What a truck load of BS. I would demand to see that gas so you can take a sample to the gas station for reimbursement if that is true. But I suspect it's dealer bullshit.
#27
///// Upscale Zoom-Zoom
Thread Starter
Here's the actual Mazda dealer invoice and the gas sample that took some time to materialize. Help me with their logic:
(1) PREMIUM fuel should not be used (owners manual states premium is required)
(2) car was found to be running 15% lean (wouldn't excessive alcohol in fuel cause it to run rich)
(3) gas sample took 11 minutes to show up after I asked (hmm...and no test data available)
(4) gas sample appears to have a large volume of water in bottom phase (how did the car run?)
invoice from today's dealer visit
bad gas from my running 2010 GT
Last edited by wannawankel; 02-08-2017 at 05:20 PM.
#29
///// Upscale Zoom-Zoom
Thread Starter
The reason I took the car to the dealer was to confirm issues with the cat (glowing on top). Now I'll have to invest in a better OBD-II reader to monitor a bunch of functions and hope the cat throws a code before the dealer spends even more money on a new cat and engine under warranty.
Would premix cause any of this from a fuel standpoint or taxing the stock cat more?
Would premix cause any of this from a fuel standpoint or taxing the stock cat more?
#30
Registered
iTrader: (1)
Join Date: May 2016
Location: Colo'freakin'rado
Posts: 542
Likes: 0
Received 0 Likes
on
0 Posts
I'm not sure about premix... and I rail the **** out of my 8 once it gets warm... annnnnnd as far as premium fuel goes we max out at 91 out here in good ol' Colorado... sooo I don't know what to tell you aside from horse ****. Granted, I'm no longer running the stock cat and I premix.
#31
///// Upscale Zoom-Zoom
Thread Starter
correct E85 is leaner but the sensor would then way over enrich the fuel to air to get stoichiometric right. The dealer said that this so-called E85 leaned the mixture.
#32
Registered
This is track data, so it is not wholly applicable, but look at the left side of the graph. My EGT is over 1100F while just sitting in grid. My first lap is taken lazily as I let my oil reach operating temp and put some heat into my brakes and tires. My second lap isn't driven much harder. Even when taking it easy, the temp shoots right past 1700F. The inch or so on the right side of the graph is my cool-down lap and return to paddock. Still much hotter than what Magnaflow specifies as the operating temp of their replacement cats.
The graph represents about 12 laps, including warm-up and cool-down laps.
This has me curious, so next time I drive the car to work, which is about 21 miles of mostly city driving, I will try to remember to run my data logger and post what EGTs are recorded during normal driving.
.
The graph represents about 12 laps, including warm-up and cool-down laps.
This has me curious, so next time I drive the car to work, which is about 21 miles of mostly city driving, I will try to remember to run my data logger and post what EGTs are recorded during normal driving.
.
#33
Super Moderator
OP, spot on advise from 9K, as always.
He will always look out for you and others, just don't muck him around.
He will always look out for you and others, just don't muck him around.
#34
Water Foul
I drove my 8 to work this morning and logged the trip in Torque. Ambient temp was 48F. Shift points were around 5000 RPM. The trip was 20.5 miles of city driving, with many stop lights, and top speeds reaching 55mph.
As you can see, just daily driving an 8 produces EGTs high enough to kill most cats, assuming Magnaflow's operating temp of 1200F is to be believed.
As you can see, just daily driving an 8 produces EGTs high enough to kill most cats, assuming Magnaflow's operating temp of 1200F is to be believed.
#35
SARX Legend
iTrader: (46)
Yeah the ECU would try and correct but it would take a lot of E85 to really lean it out since it is so rich on the factory map. And like I said, with straight E85 or even a large quantity of it, it would not run or would sputter and stall and just run like ****.
I really have to monitor my E85 mixture because "E85" can be anywhere from E50 to E85 depending on the station and when mine is off, the car runs like **** since it is tuned for it. I use the same station test it fairly often.
#36
///// Upscale Zoom-Zoom
Thread Starter
What are the requirements for inlet and outlet gas temps and other specifications for the RX8 cat to say whether a cat is failing or has failed?
#37
///// Upscale Zoom-Zoom
Thread Starter
A quick update that still has me questioning the dealer's diagnosis. I called and talked over the issues with the Service Manager and the techician who worked on the car - net I'm still suspecious that this $99 diagnosis was run up for extra cash to meet the "weekly quota" on income.
PREMIUM - dealer still stands behind that PREMIUM gas in an RX-8 is overkill especially in Winter (lie)
BAD GAS - they mentioned that they used water to determine that the gas was very high in ethanol near E-85. Milky organic (gas) phase indicated to them that the gas was high in ethanol content. No quantitative measures no record of the ST/LT fuel trims nor exhaust temperatures were recorded in their system. In my line of work, no data is just that.
I will invest in better tech to monitor the health of the catalyst and the car and do it more myself. I'm not going back to that Mazda dealer, even for an oil change. They made $250 extra on me and lost a client. PM me if you want to know what dealer this was (or look closer at the invoice).
PREMIUM - dealer still stands behind that PREMIUM gas in an RX-8 is overkill especially in Winter (lie)
BAD GAS - they mentioned that they used water to determine that the gas was very high in ethanol near E-85. Milky organic (gas) phase indicated to them that the gas was high in ethanol content. No quantitative measures no record of the ST/LT fuel trims nor exhaust temperatures were recorded in their system. In my line of work, no data is just that.
I will invest in better tech to monitor the health of the catalyst and the car and do it more myself. I'm not going back to that Mazda dealer, even for an oil change. They made $250 extra on me and lost a client. PM me if you want to know what dealer this was (or look closer at the invoice).
#38
SARX Legend
iTrader: (46)
Yeah man, it's BS. They are just so used to taking advantage of people who don't know ****.
As for the temp range, I am not sure but if the difference is significant, then I would say the cat is bad from what I have seen because it just means that the heat is staying in the cat.
As for the temp range, I am not sure but if the difference is significant, then I would say the cat is bad from what I have seen because it just means that the heat is staying in the cat.
#39
///// Upscale Zoom-Zoom
Thread Starter
BTW rotarheads - mazda has an email address to address complaints: MazdaCustomerExperience@mazdausa.com
I just filled out my Mazda survey honestly and told them I wold have been better off purchasing a OBD-II reader and tablet than to spend the $349 to hav ethe car returned to me with "fresh" gas and the cat still "slightly" glowing on occasion.
I just filled out my Mazda survey honestly and told them I wold have been better off purchasing a OBD-II reader and tablet than to spend the $349 to hav ethe car returned to me with "fresh" gas and the cat still "slightly" glowing on occasion.
#40
Just install a race pipe keep your cat, re-install cat for emissions if you have to in your area. Dont get a resonated mid pipe or anything with packing, let your 8 breathe for once. Buy an extra read o2 sensor for when you do emissions. Dont keep the cat on.. my 8 blew a hole right through the center of the packing about the size of my fist..
#41
///// Upscale Zoom-Zoom
Thread Starter
I finally had a chance to monitor the cat temps today on my 14 mile - 45 min commute home. Here's the catalyst temps and coolant temps from ~ 30 % stop and go traffic and the rest spirited highway miles. See any issues in the Series II (S2) coolant temps or cat tempos on this average day?
IAT = 75 °F, 40% rh
IAT = 75 °F, 40% rh
IAT = 75 °F, 40% rh
IAT = 75 °F, 40% rh
#43
///// Upscale Zoom-Zoom
Thread Starter
Jastreb: Yes the last portion of the trip was stop and go traffic. I need to fix the macro that imports this specific data into my stats software (SAS) so that the date/time doesn't appear like I drive a Land Rover.
#45
///// Upscale Zoom-Zoom
Thread Starter
Thanks - just getting the car and monitoring ready for my trip to DGRR
#46
Have you done a visual inspection on the cat yet?
I suspect those "cat temps" are more like exhaust gas temps, and so may not indicate a bad cat.
Also, are your STFT and LTFT's reasonable now?
I suspect those "cat temps" are more like exhaust gas temps, and so may not indicate a bad cat.
Also, are your STFT and LTFT's reasonable now?
#47
///// Upscale Zoom-Zoom
Thread Starter
Short Term and Long Term Fuel trims
I have and on occasion I can still see a faint glow coming from the top of the cat. I see this glow indirectly along the "ceiling" of the underbody. ST and LTFT are
Last edited by wannawankel; 04-22-2017 at 06:47 AM. Reason: spelling